Effect of stage of growth and silage additives on whole crop cereal silage nutritive and fermentation characteristics
J. L. Jacobs A C , J. Hill B and T. Jenkin AA Department of Primary Industries, 78 Henna Street, Warrnambool, Vic. 3280, Australia.
B School of Agriculture and Food Systems, Faculty of Land and Food Resources, University of Melbourne, Parkville, Vic. 3010, Australia.
C Corresponding author. Email: joe.jacobs@dpi.vic.gov.au
Animal Production Science 49(7) 595-607 https://doi.org/10.1071/EA08244
Submitted: 29 September 2008 Accepted: 1 April 2009 Published: 11 June 2009
Abstract
The efficient production and subsequent utilisation of home-grown forage is seen as the cornerstone of profitability of the dairy industry as it leads to lower unit costs of milk production compared with purchased forage or grain supplements. Cereals such as wheat (Triticum aestivum L.), oats (Avena sativa L.) and triticale (Triticum × Triticosecale) all have the potential to produce high forage dry matter (DM) yields. These forages are not widely grown within dryland Australian dairy systems and there is a paucity of information on both the agronomic requirements and subsequent ensiling and feed-out management under these conditions. The experiment reported in this paper examines the DM yield, nutritive and ensiling characteristics of three small-grain cereals (triticale, wheat and oats) cut at various stages of development and ensiled with or without silage additives. We hypothesised that: (1) delaying harvesting until later stages of growth would result in higher DM yields, but negatively impact on both nutritive and fermentation characteristics of subsequent silages; (2) ensiling wilted material at earlier harvests would improve fermentation characteristics compared with direct ensiled material; and (3) the use of silage additives at all harvests would improve fermentation characteristics of resultant silages compared with untreated silages. Apart from winter oats, the estimated metabolisable energy of forages was highest at the boot stage of growth, declined during anthesis and then rose again during milk and soft-dough stage of growth. The crude protein content of forages declined with maturity, with final values at soft dough below 90 g/kg DM. Neutral detergent fibre content was highest at anthesis and then declined, with lowest values observed at soft dough (497–555 g/kg DM). In the majority of cases silages were well preserved, with direct ensiled material having pH values generally below 4.5 and wilted material below 5.0, with limited proteolysis as assessed by ammonia-N contents in the range of 5–15% of total-N. The production of volatile fatty acids and lactic acid was influenced by wilting and the use of additives. Generally, wilted silages fermented less than the corresponding direct ensiled forages, whereas the use of Sil-All 4 × 4 additive resulted in a lactic acid-dominant fermentation compared with LaSil additive, which resulted in a greater proportion of acetic acid as an end product of fermentation. The findings of the present study highlight the potential of forage cereals to produce high DM yields for whole crop cereal silage. The timing of harvest directly influences nutritive characteristics of forages for ensiling. The use of silage additives can assist in controlling fermentation pathways during ensilage, ensuring the production of silages with fermentation attributes more likely to lead to higher intakes when fed to animals.
Acknowledgements
The authors acknowledge the Victorian Government, Dairy Australia, WestVic Dairy, Gipps Dairy and Murray Dairy for providing financial assistance for this study. We also thank DemoDAIRY for the use of land on their farm to undertake the experiment. The technical support of Stewart Burch, and Robyn Bush and biometrical analyses by Gavin Kearney are also acknowledged.
Bastiman B
(1976) Factors affecting silage effluent production. Experimental Husbandry 31, 40–46.
Chapman DF,
Kenny SN,
Beca D, Johnson IR
(2008a) Pasture and forage crop systems for non-irrigated dairy farms in southern Australia. 1. Physical production and economic performance. Agricultural Systems 97, 108–125.
| Crossref | GoogleScholarGoogle Scholar |
Chapman DF,
Kenny SN,
Beca D, Johnson IR
(2008b) Pasture and forage crop systems for non-irrigated dairy farms in southern Australia. 2. Inter-annual variation in forage supply, risk and business risk. Agricultural Systems 97, 126–138.
| Crossref | GoogleScholarGoogle Scholar |
Clarke T,
Flinn PC, McGowan AA
(1982) Low cost pepsin–cellulase assays for prediction of digestibility of herbage. Grass and Forage Science 37, 147–150.
| Crossref | GoogleScholarGoogle Scholar |
Crovetto GM,
Galassi G,
Rapetti L,
Sandrucci A, Tamburini A
(1998) Effect of the stage of maturity on the nutritive value of whole crop wheat silage. Livestock Production Systems 55, 21–32.
| Crossref | GoogleScholarGoogle Scholar |
de Ruiter JM,
Hanson R,
Hay AS,
Armstrong KW, Harrison-Kirk RD
(2002) Whole crop cereals for grazing and silage: balancing quality and quantity. Proceedings of the New Zealand Grassland Conference 64, 181–189.
Filya I
(2003) Nutritive value of whole crop wheat silage harvested at three stages of maturity. Animal Feed Science and Technology 103, 85–95.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Filya I,
Ashbell G,
Hen Y, Weinberg ZG
(2000) The effect of bacterial inoculants on the fermentation and aerobic stability of whole crop wheat silage. Animal Feed Science and Technology 88, 39–46.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Fussell RJ, McCalley DV
(1987) Determination of volatile fatty acids (C2–C5) and lactic acid in silage by gas chromatography. Analyst 112, 1213–1216.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Hill J, Leaver JD
(1999) Effect of stage of growth at harvest and level of urea application on chemical changes during storage of whole crop wheat. Animal Feed Science and Technology 77, 281–301.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Hill J, Leaver JD
(2002) Changes in chemical composition and nutritive value of urea-treated whole-crop wheat during exposure to air. Animal Feed Science and Technology 102, 181–195.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Hill J,
Xiao GQ, Ball AS
(2001) Effect of inoculation of herbage prior to ensiling with Streptomyces achromogenes ISP 5028 on chemical composition of silage. Animal Feed Science and Technology 89, 83–96.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Jacobs JL,
Cook JE, McAllan AB
(1991) Enzymes as silage additives 2. The effect of grass dry matter content on silage quality and performance of sheep. Grass and Forage Science 46, 191–199.
| Crossref | GoogleScholarGoogle Scholar |
Jacobs JL,
Morris RJ, Zorrila-Rios J
(1995) Effect of ensiling whole grain barley with pasture on silage quality and effluent production, and the performance of growing cattle. Australian Journal of Experimental Agriculture 35, 731–738.
| Crossref | GoogleScholarGoogle Scholar |
Kaiser AG,
Mailer RJ, Vonarx MM
(1995) A comparison of Karl Fischer titration with alternative methods for the analysis of silage dry matter content. Journal of the Science of Food and Agriculture 69, 51–59.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Kaiser AG,
Dear BS, Morris SG
(2007) An evaluation of the yield and quality of oat–legume and ryegrass–legume mixtures and legume monocultures harvested at three stages of growth for silage. Australian Journal of Experimental Agriculture 47, 25–38.
| Crossref | GoogleScholarGoogle Scholar |
Moon NJ
(1983) Inhibition of the growth of acid tolerant yeasts by acetate, lactate and propionate and their synergistic mixtures. Journal of Applied Bacteriology 55, 453–460.
|
CAS |
Nadeau E
(2007) Effects of species, maturity and additive on the feed quality of whole crop cereal silage. Journal of the Science of Food and Agriculture 87, 789–801.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
Oldham JD
(1984) Protein-energy interrelationships in dairy cows. Journal of Dairy Science 67, 1090–1114.
|
CAS |
PubMed |
Oude Elferink SJWH,
Krooneman J,
Gottschal JC,
Spoelstra SF,
Faber F, Driehuis F
(2001) Anaerobic conversion of lactic acid to acetic acid and 1,2-propanediol by Lactobacillus buchneri. Applied and Environmental Microbiology 67, 125–132.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
PubMed |
Shenk JS, Westerhaus MO
(1991) Population definition, sample selection and calibration procedures for near infrared reflectance spectroscopy. Crop Science 31, 469–474.
van Soest PJ, Wine RH
(1967) Use of detergents in the analysis of fibrous feeds. IV. Determination of plant cell wall constituents. Journal of Official Analytical Chemists 50, 50–55.
|
CAS |
Virgona JM,
Gummer FAJ, Angus JF
(2006) Effects of grazing on wheat growth, yield, development, water use, and nitrogen use. Australian Journal of Agricultural Research 57, 1307–1319.
| Crossref | GoogleScholarGoogle Scholar |
Weinberg ZG,
Ashbell G,
Hen Y, Harduf Z
(1991) Ensiling whole wheat for ruminant feeding at different stage of maturity. Animal Feed Science and Technology 32, 313–320.
| Crossref | GoogleScholarGoogle Scholar |
Williams CC,
Froetschel MA,
Ely LO, Amos HE
(1995) Effects of inoculation and wilting on the preservation and utilization of wheat forage. Journal of Dairy Science 78, 1755–1765.
|
CAS |
PubMed |
Zadoks JC,
Chang TT, Konzak CF
(1974) A decimal code for the growth stages of cereals. Weed Research 14, 415–421.
| Crossref | GoogleScholarGoogle Scholar |
Zahiroddini H,
Baah J,
Absalom W, McAllister TA
(2004) Effect of an inoculant and hydrolytic enzymes on fermentation and nutritive value of whole crop barley silage. Animal Feed Science and Technology 117, 317–330.
| Crossref | GoogleScholarGoogle Scholar |
CAS |
